Friday, July 25, 2014
Text Size

Pipeline rupture report raises questions about TransCanada inspections

2011 report criticized TransCanada’s ‘inadequate’ inspections

By Amber Hildebrandt, CBC News

A CBC News investigation has unearthed a critical report that the federal regulator effectively buried for several years about a rupture on a trouble-prone TransCanada natural gas pipeline.

On July 20, 2009, the Peace River Mainline in northern Alberta exploded, sending 50-metre-tall flames into the air and razing a two-hectare wooded area.

Few people ever learned of the rupture — one of the largest in the past decade — other than the Dene Tha’ First Nation, whose traditional territory it happened on.

In an early 2011 draft report about the incident, the National Energy Board criticized TransCanada, the operator of the line owned by its subsidiary NOVA Gas Transmission, for “inadequate” field inspections and “ineffective” management.

Final reports are typically published by the investigative bodies, either the NEB or the Transportation Safety Board, but this report wasn’t released until this January when the CBC obtained it through an access-to-information request.

The NEB said the delay was caused by an “administrative error” when an employee left without transferring the file over.

TransCanada did not respond to a CBC request for an interview.

Timing questioned

Environmental policy expert Nathan Lemphers says he’s “deeply concerned” that the federal regulator kept the “fairly damning” report behind closed doors.

“It’s quite likely that there are other incidents like this that the public simply doesn’t know about,” said Lemphers, a former Pembina Institute analyst. “This one stands out simply because of its size and the timing and the company involved.”

Lemphers questions whether TransCanada’s contentious Keystone XL proposal, under environmental review in the U.S. at the same time, had a bearing on the regulator not publishing the Peace River Mainline draft report.

“It's hard to guess intentions,” said Lemphers. “It certainly seems fishy from the outside that this report was kept quiet due to an apparent administrative error. If the report came out it would have been, risen to immediate public attention.”

In January 2011, TransCanada was in the midst of negotiating dozens of U.S. safety requests on pipeline construction, operation and design on the controversial Keystone XL proposal. That was followed by several months of public comments in the States later that year.

The Keystone XL project, first proposed in 2008, is still in limbo. A crucial assessment released last week said there are no major environmental objections to the $7-billion mega-project, but a 90-day comment period still remains.

Big ball of fire’

Members of Dene Tha’ First Nations community of Chateh, about 50 kilometres away from the site of the blast, also want to know why the report was not released until now.

“They should let the public know about these deficiencies that exist,” said Baptiste Metchooyeah, the former Dene Tha’ First Nation lands director. “We have to start saying something about these incidents, because the regulator is not there for us.”

According to the report, the pipeline spewed 1.45 million cubic metres of natural gas – equivalent to the volume of 580 Olympic-sized pools – over a period of hours before TransCanada stopped the flow and put out the fire.

Fabian Chonkolay, a local hunter who flew over the site, described the aftermath as looking like a “big ball of fire” had consumed the forest. “Just like when they drop a bomb,” he said.

Chateh residents fear that because the area is remote, it might be considered a low-risk area for pipeline operators, leading to fewer safety precautions. The pipeline runs under the community of Chateh, and hunters and trappers often travel in the area.

“It’s way in the bush, but there’s a lot of activities going on out there,” said Chonkolay.

High rate of ruptures

The report reveals that the Peace River Mainline has a historically high rate of ruptures — six since the 1970s. The Alberta pipeline’s rupture rate is five times higher than Canada’s national rupture rate, reported in a 2004 study.

The pipeline had an uncommon problem: a bacteria that caused “particularly aggressive growth rates” of corrosion. But, as the NEB report notes, the bacteria was a known threat to the pipeline and caused a rupture in 2002.

The section of the pipeline that burst in 2009 was 95 per cent corroded. TransCanada’s own rules required that it physically inspect a pipeline when it reached 75 per cent corrosion, the report says.

The report notes the inline inspection tool failed to accurately assess the depth of the “corrosion within corrosion.”

Pipeline integrity experts say that given the pipeline’s high rate of ruptures and its known corrosion problems, the company ran along the “ragged edge” of the rules. Many operators use far lower thresholds, closer to 40 or 50 per cent corrosion, before inspecting.

The NEB says that since the incident, TransCanada changed criteria for identifying corrosion, while the NEB made changes to its management requirements for pipeline operators.

“The delay in publishing this report to our external website in no way compromised the safe operation of the Peace River Mainline,” said NEB spokeswoman Rebecca Taylor.

For the Dene Tha’ First Nations community that lives above the pipeline, the focus is on what happens in the future.

In 2010, TransCanada began signalling its intent to decommission a 266-kilometre southern section of the line, built in 1968. The NEB is holding public hearings soon to get input as it decides whether to approve the move and the conditions.

But the section under review for decommissioning doesn’t extend into the northern Alberta region where Chonkolay lives.

“It’s an old pipeline,” said Chonkolay. “Heaven knows how many more damage it’s going to do in the future. … How many more times is it going to rupture?”

How CBC obtained the report

Taylor wrote in an email that the investigation closed Jan. 19, 2011.

The report on the 2009 rupture sat in draft stage for nearly three years, only coming to light when CBC obtained a copy this January.

CBC asked for the report last October on at least four separate occasions. NEB refused to release the report to CBC News, saying that it could be requested through access-to-information.

When the report was released, the final report was dated November 2013. A one and a half page section on TransCanada’s field inspection was redacted in the 2011 draft and changed in the final report.

NEB says they asked CBC to request the document through access to information to meet “legal and confidentiality obligations associated with the release of the document.”

Whatever Trevor

Dis is Trevor.

Blast from the past: FP archive

When is Consultation, Consultation?

Write comment (10 Comments)

Ovide Mercredi

National Chief – AFN

During a Treaty Roundtable meeting of the Alberta Chiefs, I took note of a federal government document outlining their strategy to define and ultimately impose their own form of self-government. Read more...

Letting go of residential schools

Write comment (7 Comments)

by Gilbert Oskaboose, Nov 1993 First Perspective

There is a lot of "unfinished business" in Indian Country. Garbage that we as a people have never really dealt with. Chief among them is the whole issue of those infamous residential schools and their impact on people. Read more...

OBIDIAH

obidiah picture

ANALYSIS - Bill Gallagher

gallagher picture

Under the Northern Sky by Xavier Kataquapit

Under the Northern Sky by Xavier Kataquapit

EVENTS

July 2014
S M T W T F S
29 30 1 2 3 4 5
6 7 8 9 10 11 12
13 14 15 16 17 18 19
20 21 22 23 24 25 26
27 28 29 30 31 1 2
Fri Jun 27 @12:00AM
Adäka Cultural Festival
Wed Jul 23 @ 9:00AM - 05:00PM
Asinabka Film Media Arts Festival
Sun Jul 27 @12:00AM
World Indigenous Business Forum 2014
imageimageimageimageimage
cartoonscartoonscartoonscartoonscartoons

Current Video

RIP Percy Tuesday

Write comment (1 Comment)

 

Thanks to Althea Guiboche for allowing The First Perspective to share her video taken at the Manitowapow book launch at McNally Robinson. 

Percey sings Freddy Fender's "Wasted Days and Wasted Nights" and people join in to harmonize. 

Last Week Tonight with John Oliver (HBO): The Washington Redskins

Write comment (0 Comments)